Smith v. Yamaha Motor Corp. (Complete Opinion)
Annotate this Case
Download PDF
J. A23016/09 2010 PA Super 154 JEFFREY SMITH AND SUSAN SMITH, HIS WIFE, Appellants : : : : v. : : YAMAHA MOTOR CORPORATION, U.S.A., : A CALIFORNIA CORPORATION, YAMAHA : INTERNATIONAL CORPORATION, A : CALIFORNIA CORPORATION, AND : YAMAHA MOTOR MANUFACTURING : CORPORATION OF AMERICA, A GEORGIA : CORPORATION, : : Appellees : IN THE SUPERIOR COURT OF PENNSYLVANIA No. 1313 WDA 2008 Appeal from the Order Entered July 21, 2008, in the Court of Common Pleas of Armstrong County, Civil Division, at No. 2001-0669. BEFORE: BENDER, BOWES AND CLELAND *, JJ. OPINION BY BOWES, J.: Filed: August 18, 2010 Jeffrey and Susan Smith appeal from the July 21, 2008 order granting summary judgment in favor of Yamaha Motor Corporation, U.S.A., Yamaha International Corporation, and Yamaha Motor Manufacturing Corporation of America (collectively Yamaha ). After careful review, we reverse and remand. At approximately 5:30 p.m. on September 23, 1999, Mr. Smith, an experienced off-road all-terrain-vehicle ( ATV ) user, was operating a 1987 Yamaha Big-Bear 350 ATV on a trail located near Cherry Run Road, Burrell Township, Armstrong County, when he had an accident. Mr. Smith, who was * Retired Senior Judge assigned to the Superior Court. J. A23016/09 wearing a helmet and gloves, was climbing a portion of the trail that climbed a steep hill. Some of his riding companions, including his daughter and her friend, had preceded him over the hill and were beyond his line of sight. Mr. Smith became concerned that if he traveled over the hill, he may collide with someone. He started to carefully and slowly back his ATV down the hill while keeping it in first gear. As Mr. Smith neared the bottom of the hill, his right foot slipped and struck the right-rear fender of the ATV. The fender collapsed, and Mr. Smith s right leg became trapped between the ATV s frame and its rear wheel. As a result, the vehicle rolled backwards over Mr. Smith s body, struck him in the face, and caused severe injuries that required comprehensive facial surgery, stitches, and splints. 1 Complaint, 5/29/01, at 8 ¶30. Mr. Smith became physically disabled and disfigured and suffers from double vision, seizures, depression, anxiety, and sleep disorders. Appellants instituted this action on May 29, 2001, seeking damages resulting from the accident. In the complaint, Appellants asserted claims sounding in breach of warranty, strict liability, and negligence. Appellants 1 At his deposition, Mr. Smith explained that his helmet did not cover his face. See Deposition of Jeffrey Smith, 3/12/02, at 102. It did have a plastic shield that was designed to prevent dust particles and insects from striking the user s face, but Mr. Smith was not utilizing the shield at the time of the accident because the area where he was riding was not dusty. Id. at 156157. As a result, Mr. Smith s face was unprotected when the ATV flipped over and the vehicle s handlebars struck him in the head. -2- J. A23016/09 notified Yamaha that the accident occurred when Mr. Smith s leg contacted the rear fender of the subject vehicle and the rear fender then collapsed, causing Plaintiff Jeffrey Smith s leg to become trapped between the rear wheel and subject vehicle s frame, thus precipitating injuries and damages as more fully set forth below. Complaint, 5/29/01, at ¶16. averred rear that the component fender, fender Appellants attachment, and instrument panel were defective. Id. at ¶18. Appellants further delineated that the accident, injuries, and damages that Appellants sustained were the result of these and other actions by Yamaha: a. In designing the rear fender, fender attachment, and/or instrument panel in such a deficient manner as to permit the subject vehicle and/or components thereof to be defective; b. In failing to properly design, construct, and/or install the instrument panel, rear fender, and/or fender attachment; .... n. In failing to design and provide a rear fender, fender attachment, and instrument panel that would be capable of being effective, safe, and practical; .... p. In failing to adequately attach the rear fender in order to prevent the fender from folding up under normal loads; q. In utilizing a rear fender that unreasonably and dangerously allowed a rider s leg to contact the rear wheel and muffler; -3- J. A23016/09 r. In allowing the rear fender mounting bolt to not have a washer that would have prevented the bolt head from pulling through the plastic fender material; .... t. In failing to properly attach and/or brace the rear fender properly so as to ensure that it would not present a danger during foreseeable use by operators[.] Id. at ¶27. Yamaha filed an answer and new matter asserting that Mr. Smith was contributorily negligent and that he assumed the risk of injury by virtue of his careless, reckless, and negligent conduct. 10/5/01, at 15 at ¶142. Answer and New Matter, Yamaha also denied the existence of a design defect or inadequate safety warnings and claimed that no warranties had been made to Mr. Smith because he purchased the ATV as a used vehicle. During Mr. Smith s deposition, he described his actions and thought process during the relevant time frame. He was ascending a hill behind his traveling companions when he reached a point where he could not see over the crest. Mr. Smith explained, I was afraid that I d have to give [the ATV] a little too much gas to crest the hill and that I would be airborne. If, in fact, one of the kids [were] up there and looked over to see where I was at or for that matter one of the adults, but I was worried about the children mainly, I was fearful I may crest the hill and go in the air and have one of -4- J. A23016/09 them in front of me. Deposition of Jeffrey Smith, 3/12/02, at 176. Mr. Smith concluded that going over the hill was not a safe option. Mr. Smith stopped the ATV and positioned himself so that he could descend safely. He placed the vehicle in drive in first gear because he did not believe that he could back down slowly enough in reverse. Since it was engaged in first gear when Mr. Smith applied gas to the vehicle, the wheels would move backwards very slowly. He had descended hills in this manner on many occasions. Id. at 182. He remained standing on the foot pegs and leaning forward. When Mr. Smith had nearly reached the bottom of the hill, the following occurred: It [was] just like one moment I was standing up, the next moment my leg was sucked into the wheel, stuck between the fender and the tire, getting burned by the muffler and the [ATV] rolled backwards, head over heels. Id. at 187. Mr. Smith explained that the vehicle started to flip backwards for the following reason: Whenever the fender gave way, it lodged my foot between the fender top, the muffler and the internal portion of the wheel and the top of the tread. It had to have stopped everything when my leg got stuck in the there. And I m assuming that that instantaneous stop and the fact that it sucked me down to the right and threw my weight over to the right-hand side, you know, a rapid jerk, I lost . . . not only my balance, but my center of gravity, I lost everything. I -5- J. A23016/09 lost my ability to control the rearward motion; I lost everything momentarily. Id. at 205. Mr. Smith stated that he later saw the detached fender and that the bolt that secured the right rear fender to the frame of the ATV had broken through the plastic fender. When asked if he had ingested any drugs or alcohol on the day of the accident, Mr. Smith stated that he drank one twelve-ounce beer sometime before 4:00 p.m. He also was ingesting approximately 120 milligrams of the painkiller OxyContin under prescription on a daily basis due to a degenerative spinal condition that caused chronic neck and back pain. Id. at 112-114, 129-133. He stated that he was permitted to drink alcohol while using OxyContin but was cautioned to use extreme care. Id. at 133. His blood alcohol content had been tested on the day of the accident, and it was .021%, which is approximately seventy-five percent below the legal limit. Mr. Smith stated that he was not feeling any effects from the OxyContin. On April 11, 2007, Yamaha filed a motion for partial summary judgment seeking the dismissal of Appellants strict liability and breach of warranty claims on the bases that: (1) Mr. Smith was misusing the ATV when the accident occurred; and (2) the warranty claims were barred by the applicable statute of limitations. Specifically, Yamaha argued that it could not be held strictly liable for Mr. Smith s injuries because he acknowledged -6- J. A23016/09 receiving a booklet titled, Yamaha tips for the ATV rider ( tips booklet ) when he purchased the ATV, and the booklet expressly warned that operators should not use drugs or alcohol or allow the vehicle to roll backwards on a hill. See Motion, 4/11/07, at 4-5. Accordingly, Yamaha maintained that at the time of the accident, Mr. Smith was operating the vehicle in an unintended manner. Appellants filed a response addressing the viability of their strict liability claims and countered that Yamaha could not assert comparative negligence as a defense in this action. Appellants maintained that Mr. Smith s actions were wholly irrelevant and that he had, in fact, established a prima facie case against Yamaha because: (1) he was an intended user; (2) the vehicle was being used for its intended purpose, i.e., riding on dirt trails; and (3) the alleged defect was the proximate cause of Mr. Smith s injuries. Appellants disclaimed that the act of backing the ATV down a hillside constituted an unintended use of the vehicle. Appellants additionally averred that lawfully consuming prescription drugs and alcoholic beverages before operating an ATV does not absolve the manufacturer of liability for a design defect, and that even if such conduct was somehow relevant in this context, there was no indication that these actions caused the accident. Id. at 5. -7- J. A23016/09 The trial court heard oral argument on the motion on June 29, 2007, whereupon Appellants counsel withdrew the breach of warranty claims. On October 17, 2007, the court granted summary judgment in favor of Yamaha on the strict liability claims. Appellants motion for reconsideration was denied, and the court declined to certify its order for immediate appeal. Thus, Appellants were left solely with their negligence claims predicated upon, inter alia, allegations of negligent design, failure to adequately test the rear fender s ability to withstand intense blows, and failure to warn of the risk of injury posed by a collapsed fender. Yamaha filed a motion for summary judgment as to the negligence claims on January 14, 2008. On February 29, 2008, the trial court heard argument on that motion as well as a motion to strike two expert reports Appellants submitted with their pretrial statement. The court adjudicated the motion to strike on May 9, 2008, permitting one report to stand but striking the second on the basis that it raised a new legal theory [of recovery] after the expiration of the relevant Statute of Limitations. . . . Opinion and Order, 5/9/08, at 6. See, e.g., Rachlin v. Edmison, 813 A.2d 862 (Pa.Super. 2002) (en banc) (an expert report cannot introduce a new cause of action after the statute of limitations has run because it is prejudicial to the adverse party). Thereafter, on July 21, 2008, the court granted Yamaha s motion for summary judgment and disposed of all -8- J. A23016/09 remaining claims. This timely appeal followed, wherein Appellants challenge both summary judgment rulings and the grant of Yamaha s motion to strike the expert report of accident reconstruction expert, Dr. Robert R. Wright. Specifically, Appellants raise these contentions: Question 1: Whether the trial court erred as a matter of law by granting defendants partial motion for summary judgment as to plaintiffs strict products liability count. Question 2: Whether the trial court abused its discretion by striking the plaintiffs expert crash reconstruction report. Question 3: Whether the trial court erred as a matter of law by granting defendants motion for summary judgment as to plaintiffs negligence and/or negligent design count. Appellant s brief at 5. We begin with Appellants position that the trial court erred in striking Dr. Wright s expert report, as that ruling excluded evidence offered in support of Appellants negligence and strict liability claims. As noted, the court concluded that the report asserted a new cause of action after the applicable two-year statute of limitations had expired. Appellants argue that Dr. Wright s report addressed the absence of adequate foot and leg protection, which was clearly raised in their complaint, and that if other portions of his report raised a new cause of action, the court should have redacted those portions instead of striking the report in its entirety. The record reveals that Dr. Wright authored a report wherein he concluded that: (1) the fenders on the ATV at issue were flexible and did not -9- J. A23016/09 adequately protect the operator s feet and legs from the tires, which was problematic because the tires had a deep tread pattern that could grab shoes, clothing, and other objects; and (2) the ATV s weight distribution and center of gravity was totally inappropriate for a machine of this configuration and made the vehicle prone to forward and rearward pitch or flip-overs. Expert Report of Dr. Robert Wright, 5/25/07, at 5-6. In deciding Yamaha s motion, the trial court focused solely on the second aspect of the report but then struck the entire report on the basis that it emphasizes problems stemming from the machine s balance rather than those related to the fender and instrument panel. Opinion and Order, 5/9/08, at 8. While we agree with the trial court that Dr. Wright s analysis of the vehicle s stability raised a new theory of liability beyond the statute of limitations, we disagree with the court s decision to strike the entire report. Contrary to the trial court s position, the portion of Dr. Wright s report that addressed foot-related safety hazards did not raise a new cause of action; that analysis expounded upon an issue clearly raised in Appellants complaint. Specifically, therein, Appellants alleged that Yamaha was negligent for utilizing a rear fender that unreasonably and dangerously allowed a rider s leg to contact the rear wheel and muffler. Complaint, 5/29/01, at 27(q). Appellants accurately point out that the court should not - 10 - J. A23016/09 have stricken this aspect of the report 2 and, therefore, we will consider the relevant excerpts in determining whether the trial court erred in granting summary judgment to Yamaha. At the outset, we note our standard of review: We may reverse the entry of summary judgment only where we find that the trial court erred in concluding that either (1) no genuine issue of material fact existed; or (2) the moving party was entitled to judgment as a matter of law. We must review the record in the light most favorable to the nonmoving party, resolving all doubts and drawing all inferences against the moving party. As this inquiry involves purely questions of law, our review is plenary. Finally, we are not bound by the conclusions of law of the trial court, as we may reach our own conclusions and draw our own inferences. Glikman v. Progressive Casualty Insurance Company, 917 A.2d 872, 872-873 (Pa.Super. 2007) (quoting Roth Cash Register Company, Inc. v. Micro Systems, Inc., 868 A.2d 1222, 1225 (Pa.Super. 2005)). We now review whether the court erred in granting summary judgment in favor of Yamaha on the strict liability claims. Appellants argue that the court improperly based its ruling on the existence of a warning tag that was not included in the record and that the court misapplied pertinent legal principles articulated in Pennsylvania Department of General 2 We do not agree with Yamaha s contention that Appellants waived their averment in this regard. Appellants clearly argued that the report should not be stricken based upon the discovery violation raised by Yamaha as well as that the report did not raise a new cause of action after the applicable statute of limitations. - 11 - J. A23016/09 Services v. United States Mineral Products Co., 898 A.2d 590 (Pa. 2006). We concur with the latter claim and need not address the former. The record establishes that in granting summary judgment on Appellants product liability claims, the trial court accepted Yamaha s argument that Mr. Smith misused the ATV at the time of the accident because he ingested OxyContin and beer prior to riding the vehicle. Trial Court Opinion, 10/17/07, at 4. See Specifically, the court reasoned that under Pennsylvania Department of General Services v. United States Mineral Products Co., supra, the [act] of taking OxyContin and consuming alcohol clearly contravenes the manufacturer s warnings [against such conduct] and constitutes an unintended use [of the vehicle]. (footnote omitted). Id. The court therefore granted Yamaha s motion and declined to address its alternate claim that permitting the ATV to roll backwards on a hill also constituted an unintended use of the vehicle. Id. at n.2. In support of the trial court s finding that the ATV was not being employed in accordance with its intended use, Yamaha relies upon our Supreme Court s decisions in Pennsylvania Department of General Services, supra, and Phillips v. Cricket Lighters, 841 A.2d 1000 (Pa. 2003) (plurality opinion by Justice Cappy with three justices concurring). In the former case, Monsanto Company ( Monsanto ) was sued in a product - 12 - J. A23016/09 liability action based upon allegations that hazardous chemicals that were contained in its building material were present throughout a building owned by the Commonwealth. A fire occurred on one floor of the Commonwealth building, and following that event, the chemicals were detected on surfaces and in the ambient air throughout the structure. Eventually, the Commonwealth decided to destroy the building, based partially upon the presence of the chemicals. The Commonwealth then instituted the action against Monsanto and other defendants under theories of strict liability and negligence and sought compensation for the damage to its property. strict liability. The case as to Monsanto was tried solely under a theory of Monsanto presented evidence that the chemicals were released during the fire rather than when its building materials were in the extant building, and the Commonwealth prevailed. On appeal, Monsanto complained, among other things, about the trial court s refusal to instruct the jury that it was liable only to the extent that the chemicals were released while the building materials were located within the intact structure and that it was not responsible for any chemicals released when its building materials were burned. Monsanto noted that the requested instruction was premised upon precedent which provided that a manufacturer is not liable under a products liability theory of recovery if a product is not being used in accordance with its intended use. - 13 - J. A23016/09 Our Supreme Court agreed with Monsanto s contention. It noted that building materials are not designed to be burned and, to the extent that the chemicals were released during the fire, Monsanto was not liable. Our Supreme Court held that Monsanto s product was not being used as intended while being burned, even if the fire was foreseeable. The Court ruled: As it is undisputed that the incineration of building products is not a use intended by the manufacturer, under prevailing Pennsylvania law, damages in strict liability are unavailable for the fire-related contamination [of the Commonwealth s building]. The absence of any requirement for the jurors to distinguish between the fire- and not-fire-related contamination brings the entire verdict on liability and damages into question since [Monsanto presented evidence that the chemical s dispersal in the structure was due to the fire]. . . . Id. at 604; see also Phillips, supra (manufacturer of lighter not liable for fire started by child playing with lighter since such use was not an intended use of the lighter, even if it was a foreseeable use). In the present case, the trial court erred in concluding that Mr. Smith was not using the ATV as intended. An ATV is an off-road vehicle and its intended utilization is to be driven in an off-road setting. The ATV at issue herein clearly was being used for that purpose at the time of this accident. Mr. Smith was operating the ATV on a trail in a wooded area when the accident occurred. This case bears no resemblance to either Pennsylvania Department of General Services or Phillips. - 14 - Building materials are J. A23016/09 intended to be installed in structures and not to be incinerated. Similarly, lighters are manufactured so that adults may ignite cigarettes, candles or fires; they are not designed to be utilized by children as a toy or plaything. However, ATVs are designed to be driven in an off-road setting, and Mr. Smith was utilizing the ATV in that capacity when the accident occurred. Hence, the trial court misapplied the doctrine examined in Pennsylvania Department of General Services and Phillips. In the present case, the trial court conflated the doctrine of unintended use with the concept of misuse. Yamaha s defense was that Mr. Smith was not using the ATV in accordance with the instructions that he received with that vehicle. Those instructions provided that the ATV should not be used under the influence of drugs or alcohol and that the ATV should not be backed down a hill. Mr. Smith had taken OxyContin for pain associated with a pre-existing back injury in accordance with his prescription for that drug. In addition, he had imbibed a small amount of beer. Finally, he was backing his ATV down a hill in first gear in order to avoid striking other ATV users who were over the hill and out of his sightline. These actions relate to the defense of misuse of the product in that the ATV was not being used in accordance with the manufacturer s instructions. It is well-settled that a plaintiff s misuse of a product cannot be grounds for granting summary judgment in favor of the manufacturer under a design - 15 - J. A23016/09 defect theory unless it is established that the misuse solely caused the accident while the design defect did not contribute to it. See, e.g., Clark v. Bil-Jax, Inc., 763 A.2d 920 (Pa.Super. 2000). Herein, Appellants presented Mr. Smith s testimony that his use of the ATV was unaffected by his ingestion of prescription medication and one beer. Furthermore, the reports of Appellants expert witnesses established that the cause of the accident was related to the fender design and its failure to provide adequate feet and leg protection for riders. This conclusion was articulated in Dr. Wright s report, as discussed above, and further supported by the report of Dennis A. Toaspern, which was not stricken by the trial court. Mr. Toaspern opined in relevant part: When Jeffrey Smith s right foot slipped off the peg, it was thrust to the rear, where it came in contact with the rotating wheel. At this point, the fender flexed and allowed Smith s lower leg to be drawn up and into the confined space above the wheel and below the lower surface of the fender. The fender flexed excessively, that is, the fender was allowed to fold approximately 180 degrees because the attaching screw head for the fender was pulled through the clearance hole in the fender, allowing both the fender and Smith s leg to be trapped. .... It is my opinion, to a reasonable degree of accident reconstruction certainty that the cause of Mr. Smith s injuries was the failure of the fender attaching system which allowed his leg to be drawn into and trapped in the confined space above the tire and below the fender was the failure of the mounting screw to secure the fender. When the fender was allowed to bend backward, Smith s leg, instead of being held away from the tire was drawn in, entrapping it. - 16 - J. A23016/09 .... Additionally, it is my opinion that Mr. Smith s actions were proper; given the circumstances and that he was not negligent in his operation of the ATV. Expert Report of Dennis A. Toaspern, 10/15/07, at 5-6; Reproduced Record at 424a-25a. Thus, it is clear that Appellants adduced the necessary evidence to overcome Yamaha s summary judgment request as to the product liability claims based upon misuse of the product in question. Finally, we address the trial court s conclusion that summary judgment was appropriate as to the negligence and negligent design causes of action. This ruling was predicated on the fact that Appellants expert witnesses failed to delineate: (1) the availability of an alternative fender system that would have prevented the accident in question; and (2) that Yamaha knew or should have known that its design was defective. Appellants posited that Yamaha knew or should have known that its fender and component parts were defectively designed because: (1) the ATV had no foot and leg protection; (2) the design did not provide appropriate occupant protection; and (3) other contemporaneous designs contained in other ATVs possessed two variations that would have prevented the failure of the fender attachment system present in this case. Mr. Toaspern s report reads as follows in support of the averred facts: Other contemporaneous designs use a similar fastening scheme, but all provide for the bracket to extend much farther - 17 - J. A23016/09 from the frame than the Yamaha design. Also, other designs use much larger screw heads, large fender style washers or top-hat standoff washers with a large head to prevent pullthrough of the mounting screw head. Either of these two variations could have prevented the displacement and folding of the fender and the subsequent injury to Mr. Smith. Expert Report of Dennis A. Toaspern, 10/15/07, at 5-6; Reproduced Record at 424a-25a. An improperly stricken portion of Dr. Wright s report further confirmed, The state of the art at the time of design and manufacture of this [subject ATV] was such that appropriate foot and leg protection for ATVs was known and available. Expert Report of Dr. Robert Wright, 5/27/07, at 6; R.R. at 417a. The trial court acknowledged Mr. Toaspern s statement that other manufacturers designs contained systems that would have prevented the accident. The trial court concluded Mr. Toaspern s proffer was insufficient because there was no specifics as to which models have the alternative designs, which companies manufactured said models, and when. Trial Court Opinion, 7/21/08, at 8. It rejected the report of Mr. Toaspern on the basis that Appellants presented no evidence that the designs referred to by Toaspern actually exist. Id. (emphasis in original). The court continued, Without such evidence, it is impossible to conclude that said designs should have or did put [Yamaha] on notice, rendering their decision to manufacture and sell the subject ATV unreasonable. Id. - 18 - J. A23016/09 The trial court employed an incorrect standard of reviewing Appellants evidence for purposes of grant of summary judgment. As noted, for purposes of summary judgment, Mr. Toaspern s statements must be accepted as true, i.e., other manufacturers, regardless of whether or not they are named, did have in place a safe fender design that would have prevented a fender collapse. Furthermore, Dr. Wright opined that the state of art in place when the ATV herein was manufactured provided for adequate foot and leg protection for ATV users. The availability of these designs was sufficient to raise a material fact as to whether Yamaha knew or should have known of safer alternatives that would have prevented this accident. Summary judgment was therefore inappropriate as to the negligence causes of action. Order reversed. Case remanded. Jurisdiction relinquished. - 19 -
Some case metadata and case summaries were written with the help of AI, which can produce inaccuracies. You should read the full case before relying on it for legal research purposes.
This site is protected by reCAPTCHA and the Google Privacy Policy and Terms of Service apply.
